Read 42004.mss.user.ICD.2.pdf text version

SSP 42004, Part 2, Revision A

Mobile Servicing System to User (Generic) Interface Control Document Part 2 International Space Station Program

Revision A, May 22, 1997 Type 1 Approved by NASA

National Aeronautics and Space Administration International Space Station Program Johnson Space Center Houston, Texas

SSP 42004, Part 2

MSS to User ICD May 22, 1997

REVISION AND HISTORY PAGE REV. DESCRIPTION PUB. DATE

CHANGE

00­00

SSP 42004, Part 2

MSS to User ICD May 22, 1997

PREFACE

SSP 42004, Mobile Servicing System to User (Generic) Interface Control Document, Part 2, shall be implemented on all new Program contractural and internal activity and shall be included in any existing contracts through contract changes. This document is under the control of the Space Station Control Board (SSCB) with the concurrence of the respective International Partners, any changes or revisions will be approved by the SSCB and the respective International Partners.

Program Manager, International Space Station Alpha

Date

SSP 42004, Part 2

MSS to User ICD May 22, 1997

NASA/CSA INTERNATIONAL SPACE STATION PROGRAM MOBILE SERVICING SYSTEM TO USER (GENERIC) INTERFACE CONTROL DOCUMENT PART 2

Print Name

For NASA

DATE

Print Name

For CSA

DATE

i

SSP 42004, Part 2

MSS to User ICD May 22, 1997

INTERNATIONAL SPACE STATION PROGRAM MOBILE SERVICING SYSTEM TO USER (GENERIC) INTERFACE CONTROL DOCUMENT PART 2

CONCURRENCE

PREPARED BY:

PRINT NAME ORGN

SIGNATURE

DATE

CHECKED BY:

PRINT NAME ORGN

SIGNATURE

DATE

SUPERVISED BY (BOEING):

PRINT NAME ORGN

SIGNATURE

DATE

SUPERVISED BY (NASA):

PRINT NAME ORGN

SIGNATURE

DATE

DQA:

PRINT NAME ORGN

SIGNATURE

DATE

ii

SSP 42004, Part 2

MSS to User ICD May 22, 1997

CONCURRENCE INTERNATIONAL SPACE STATION PROGRAM MOBILE SERVICING SYSTEM TO USER (GENERIC) INTERFACE CONTROL DOCUMENT PART 2

Product Group­1 ICWG Representative for Concurrence

PRINT NAME

SIGNATURE

DATE

Product Group­2 ICWG Representative for Concurrence

PRINT NAME

SIGNATURE

DATE

Product Group­3 ICWG Representative for Concurrence

PRINT NAME

SIGNATURE

DATE

SPAR Representative for Concurrence

PRINT NAME

SIGNATURE

DATE

vi

SSP 42004, Part 2

MSS to User ICD May 22, 1997

INTERNATIONAL SPACE STATION PROGRAM MOBILE SERVICING SYSTEM TO USER (GENERIC) INTERFACE CONTROL DOCUMENT PART 2 LIST OF CHANGES MAY 22, 1997

All changes to paragraphs, tables, and figures in this document are shown below:

SSCBD ENTRY DATE CHANGE PARAGRAPH(S)

TABLE(S)

FIGURE(S)

APPENDIX(ES)

ADDENDA

vii

SSP 42004, Part 2

MSS to User ICD May 22, 1997 TABLE OF CONTENTS

PARAGRAPH 1.0 1.1 1.2 1.3 2.0 SECTION A3 A3 A3.1 A3.1.1 A3.1.2 A3.2 A3.3 A3.4 A3.4.1 A3.4.2 A3.4.3 A3.4.3.1 A3.4.4 A3.5 A3.6 A3.7 SECTION B3 B3 B3.1 B3.1.1 B3.1.2 B3.1.3 B3.2 B3.3 B3.4 B3.4.1 B3.4.2 B3.4.3 B3.4.3.1 B3.5 B3.6 SECTION C3 SECTION D3 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PURPOSE AND SCOPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PRECEDENCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RESPONSIBILITY AND CHANGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . APPLICABLE DOCUMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PDGF TO USER INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . INTERFACE DEFINITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . INTERFACE DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ENGINEERING UNITS AND TOLERANCES . . . . . . . . . . . . . . . . . . . . . . . . . . . STRUCTURAL/MECHANICAL INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . ENVIRONMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ELECTRICAL INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . POWER, RETURN AND GROUNDING INTERFACES . . . . . . . . . . . . . . . . . . PDGF POWER CONNECTORS AND PIN ASSIGNMENTS . . . . . . . . . . . . . . PDGF DATA AND PFM VIDEO INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . PDGF DATA AND VIDEO CONNECTORS AND PIN ASSIGNMENTS . . . . . VIDEO PROVISIONS FOR USERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . THERMAL INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SOFTWARE INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PDGF TARGET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . MCAS TO USER INTERFACE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . INTERFACE DEFINITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . INTERFACE DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DELETED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ENGINEERING UNITS AND TOLERANCES . . . . . . . . . . . . . . . . . . . . . . . . . . . STRUCTURAL/MECHANICAL INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . DELETED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ELECTRICAL INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . POWER, RETURN AND GROUNDING INTERFACES . . . . . . . . . . . . . . . . . . POWER CONNECTORS AND PIN ASSIGNMENTS . . . . . . . . . . . . . . . . . . . . DATA INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DATA CONNECTORS AND PIN ASSIGNMENTS . . . . . . . . . . . . . . . . . . . . . . . ENVIRONMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SOFTWARE INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RESERVED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RESERVED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

PAGE 1-1 1-1 1-1 1-1 2-1 A3 ­ 1 A3 ­ 1 A3 ­ 1 A3 ­ 1 A3 ­ 1 A3 ­ 1 A3 ­ 1 A3 ­ 1 A3 ­ 2 A3 ­ 2 A3 ­ 2 A3 ­ 3 A3 ­ 3 A3 ­ 3 A3 ­ 3 A3 ­ 3 B3 ­ 1 B3 ­ 1 B3 ­ 1 B3 ­ 1 B3 ­ 1 B3 ­ 1 B3 ­ 1 B3 ­ 2 B3 ­ 2 B3 ­ 2 B3 ­ 2 B3 ­ 2 B3 ­ 2 B3 ­ 2 B3 ­ 2 C3 ­ 1 D3 ­ 1

1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

E3 ­ 1 F3 ­ 1 G3 ­ 1 H3 ­ 1 I3 ­ 1 I3 ­ 1

SECTION E3 SECTION F3 SECTION G3 SECTION H3 SECTION I3 I3

RESERVED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RESERVED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RESERVED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RESERVED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FRGF TO USER INTERFACES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . INTERFACE DEFINITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

APPENDIX

APPENDIX A: APPENDIX B: ABBREVIATIONS AND ACRONYMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TBD LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A­1 B­1

FIGURES

A3.2­1 A3.2­2 A3.2­3 A3.4­1 A3.4­2 A3.4­3 A3.4­4 A3.4­5 B3.2­1 B3.2­2 B3.2­3 B3.4­1 PDGF INTERFACE TO USERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PDGF INTERFACE TO USERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PDGF INTERFACE TO USERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­4 A3 ­ 5 A3 ­ 6

PDGF TO USER (VIA SSRMS) ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 7 PDGF TO USER (VIA POA) ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 8 PDGF TO USER (VIA SPDM) ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 9 JEM­PM TO PDGF KEEP­ALIVE ELECTRICAL SYSTEM DIAGRAM . . . . . APM TO PDGF KEEP­ALIVE ELECTRICAL SYSTEM DIAGRAM . . . . . . . . . MCAS TO USER MECHANICAL INTERFACE . . . . . . . . . . . . . . . . . . . . . . . . . . MCAS TO USER MECHANICAL INTERFACE . . . . . . . . . . . . . . . . . . . . . . . . . . MCAS TO USER MECHANICAL INTERFACE . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 10 A3 ­ 11 B3­ 3 B3 ­ 4 3B ­ 5

MCAS TO USER ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM . . . . . . . . B3­ 8

TABLES

A3.4.2­1 A3.4.2­2 A3.4.2­3 A3.4.2­4 A3.4.3.1­1 A3.4.3.1­2 A3.4.3.1­3 A3.4.3.1­4 PDGF POWER FROM SSRMS (PRIME) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J7) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 12 PDGF POWER FROM SSRMS (REDUNDANT) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J8) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 13 PDGF POWER FROM POA (PRIME) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J7) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 14 PDGF POWER FROM POA (REDUNDANT) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J8) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 15 PDGF DATA AND VIDEO FROM SSRMS (PRIME) CONNECTORS AND PIN ASSIGNMENTS (J5) A3 ­ 16 PDGF DATA AND VIDEO FROM SSRMS (REDUNDANT) CONNECTORS AND PIN ASSIGNMENTS (J6) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 17 PDGF DATA AND VIDEO FROM POA (PRIME) CONNECTORS AND PIN ASSIGNMENTS (J5) . . A3 ­ 18 PDGF DATA AND VIDEO FROM POA (REDUNDANT) CONNECTORS AND PIN ASSIGNMENTS (J6) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A3 ­ 19

2

SSP 42004, Part 2

MSS to User ICD May 22, 1997

A3 ­ 20 A3 ­ 21

A3.4.4­1 A3.4.4­2 B3.4.2­1

VIDEO PROVISIONS FOR USERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DELETED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

MCAS TO USER PRIME AND REDUNDANT POWER AND DATA CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . B3­ 9

3

SSP 42004, Part 2

MSS to User ICD May 22, 1997

1.0 INTRODUCTION

1.1 PURPOSE AND SCOPE

This Interface Control Document (ICD) Part 2 defines and controls the physical and functional interfaces between the Canadian Mobile Servicing System (MSS) and Users. For purposes of this ICD, the term "user" shall be defined as any payload, pallet, or Orbit­Replaceable Unit (ORU) that interfaces with the Space Station Remote Manipulator System (SSRMS) Latching End Effector (LEE), the Special Purpose Dexterous Manipulator (SPDM) LEE, the Payload/ORU Accommodation (POA), the Mobile Base System (MBS) Common Attach System (CAS), or the SPDM manipulators.

1.2 PRECEDENCE

In the event of conflict between SSP 41000, Space Station System Specification, and the contents of this ICD, the requirements of SSP 41000 shall take precedence.

1.3 RESPONSIBILITY AND CHANGE

This document is prepared and maintained in accordance with SSP 30459, International Space Station Interface Control Plan. The National Aeronautics and Space Administration (NASA) shall delegate the responsibility for preparation and maintenance of this ICD Part 2.

1-1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

2.0 APPLICABLE DOCUMENTS

The following documents of the date and issue shown include specifications, models, standards, and form a part of this document to the extent specified herein. DOCUMENT NO. SSP 30482 Rev A, CN­001 1 Jan 1994 SSP 30482 Rev A, CN­001 1 Jan 1994 SSP 41000 Rev E 28 Jan 1997 SSQ 21635 NSTS­21000­IDD­ISS SSP 30459 SSP 42003, Part 2 SSP 42004, Part 1 TITLE Electrical Power Specification and Standards: Vol I, Electrical Performance Specifications Electrical Power Specification and Standards: Vol II, Consumer Constraints System Specification for Space Station

Electrical Connector Specifications Shuttle Orbiter/International Space Station Interface Definition Document International Space Station Interface Control Plan Space Station Manned Base to Mobile Servicing System Interface Control Document, Part 2 Mobile Servicing System (MSS) to User (Generic) Interface Control Document, Part 1

2-1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION A3 PDGF TO USER INTERFACES

A3 INTERFACE DEFINITION

A3.1 GENERAL

A3.1.1 INTERFACE DESCRIPTION

The physical interface (mechanical, structural, thermal and environmental) plane is defined at the Power and Data Grapple Fixture (PDGF) mounting ring surface to the User. The utility interface plane (power, data and video) is defined between the PDGF harness and the User connectors at the User end of the harness.

A3.1.2 ENGINEERING UNITS AND TOLERANCES

Unless otherwise noted herein, all dimensions are shown in the English system of inch pound (IP) units.

A3.2 STRUCTURAL/MECHANICAL INTERFACES

The PDGF attaches to the User via eight fasteners. The bolt hole pattern and related mechanical installation details are defined in Figures A3.2­1 through A3.2­3.

A3.3 ENVIRONMENTS

The PDGF to User electromagnetic, grounding and bonding interface implementation will be as defined in Figures A3.2­1 through A3.2­3.

A3.4 ELECTRICAL INTERFACES

The SSRMS Tip LEE will provide power, data and Pulse Frequency Modulation (PFM) sync and control, and PFM video interfaces to the User via the User PDGF as defined in Figure A3.4­1.

A3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

The MBS POA will provide power, data and PFM sync and control, and PFM video interfaces to the User via the User PDGF as defined in Figure A3.4­2. The SPDM LEE will provide power interfaces to the User via the User PDGF as defined in Figure A3.4­3 (TBD#1). The SSRMS will provide Keep­Alive power to the JEM­PM via the PDGF as defined in Figure A3.4­4. The SSRMS will provide Keep­Alive power to the APM via the PDGF as defined in Figure A3.4­5.

A3.4.1 POWER, RETURN AND GROUNDING INTERFACES

The SSRMS LEE and MBS POA will provide power, return and grounding interfaces to the User via the PDGF as shown in Figures A3.4­1 and A3.4­2. The PDGF external harness design for a User will be unique for each application. An example of a PDGF external harness design is shown in SSP 42003, Part 2, Section D.

A3.4.2 PDGF POWER CONNECTORS AND PIN ASSIGNMENTS

The PDGF power connectors and pin assignments for the User (power via the SSRMS Tip LEE) will be as defined in Tables A3.4.2.­1 through A3.4.2.­2. The PDGF power connectors and pin assignments for the User ( power via the MBS POA) will be as defined in Tables A3.4.2.­3 through A3.4.2.­4. The PDGF power connectors and pin assignments for the User ( power via the SPDM LEE) will be as defined in Tables A3.4.2.­5 through A3.4.2.­6 (TBD#2).

A3.4.3 PDGF DATA AND PFM VIDEO INTERFACES

The C & DH subsystem will support data interfaces between the User and the SSRMS LEE. The C & DH subsystem will support data interfaces between the User and the MBS POA. PFM sync and control and PFM video will be carried by copper lines between the User PDGF and the SSRMS LEE, and User PDGF and the MBS POA.

A3 ­ 2

SSP 42004, Part 2

MSS to User ICD May 22, 1997

A3.4.3.1 PDGF DATA AND VIDEO CONNECTORS AND PIN ASSIGNMENTS

The PDGF data and PFM video connectors and pin assignments for the User (via the SSRMS Tip LEE) will be as defined in Tables A3.4.3.1­1 through A3.4.3.1­2. The PDGF data and PFM video connectors and pin assignments for the User ( via the MBS POA) will be as defined in Tables A3.4.3.1­3 through A3.4.3.1­4.

A3.4.4 VIDEO PROVISIONS FOR USERS

During SSRMS or MBS POA operations, the MSS will provide video capability as defined in Table A3.4.4­1.

A3.5 THERMAL INTERFACES

The PDGF to User thermal interface implementation will be as defined in Figures A3.2­1 through A3.2­3.

A3.6 SOFTWARE INTERFACES

There are no software interfaces between the User PDGF and the SSRMS LEE or MBS POA.

A3.7 PDGF TARGET

The PDGF grapple target will have features as defined in Figures A3.2­1 through A3.2­3.

A3 ­ 3

SSP 42004, Part 2

MSS to User ICD May 22, 1997

(Reference SPAR drawing 51618­0012, sheet 1 of 3)

FIGURE A3.2­1 PDGF INTERFACE TO USERS

A3 ­4

SSP 42004, Part 2

MSS to User ICD May 22, 1997

(Reference SPAR drawing 51618­0012, sheet 2 of 3)

FIGURE A3.2­2 PDGF INTERFACE TO USERS

A3 ­ 5

SSP 42004, Part 2

MSS to User ICD May 22, 1997

(Reference SPAR drawing 51618­0012, sheet 3 of 3)

FIGURE A3.2­3 PDGF INTERFACE TO USERS

A3 ­ 6

SSP 42004, Part 2

MSS to User ICD May 22, 1997

User Provided Connectors

Bus Coupler

SSRMS LEE/User PDGF Interface Plane

SSRMS

Internal PDGF Wiring and Connectors

PDGF User Interface Plane User Determined PDGF Harness Length

1 TSP 22ga

1 TSP

1 TSP 22ga

MSS Local Bus A (LB1 A)

SSBA PFM Video 1 PFM Video 2

SSBA

Data Bus A

RD316 RD316 PFM Sync and Control 1 RD316 Payload Power A1 12ga Return A1 12ga Payload Power A2 12ga Return A2 12ga

Ground

RD316 RD316 RD316 12ga 12ga 12ga 12ga

RD316 RD316 RD316 12ga 12ga 12ga 12ga 12ga

J1

J5

J5

RPC 25A

User Bus A

Return

To User Loads

12ga

12ga

J7

J3

J7

1 TSP 22ga

MSS Local Bus B (LB1 B)

SSBA PFM Video 3

SSBA RD316

1 TSP 22ga

1 TSP 22ga

Data Bus B

RD316 RD316

RD316 RD316

PFM Sync and Control 2 RD316

J2

J6

J6

RPC 25A

User Bus B

Return

Payload Power B1 12ga Return B1 Payload Power B2

Return B2 Ground

12ga 12ga

12ga 12ga 12ga 12ga 12ga

12ga 12ga 12ga 12ga

To User Loads

12ga

J8

J4

J8

FIGURE A3.4­1 PDGF TO USER (VIA SSRMS) ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM

A3 ­ 7

É

PDGF/User Interface Plane Provided Connectors

ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ

ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ

ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ ÉÉ

SSP 42004, Part 2

MSS to User ICD May 22, 1997

PDGF/User Interface Plane Provided Connectors

User Provided Connectors POA/User PDGF Interface Plane

Bus Coupler

PDGF User Interface Plane

MBS

POA

Internal PDGF Wiring and Connectors

1 TSP

MSS Local Bus A (LB1 A)

1 TSP 22ga

1 TSP 22ga

1 TSP 22ga

SSBA

PFM Video 1 PFM Video 2

RD316 RD316 PFM Sync and Control 1RD316 Payload Power A1 Return A1 Payload Power A2 Return A2

Ground

RD316 RD316 RD316 J1 J5 12ga 12ga 12ga 12ga 12ga J3

RD316 RD316 RD316 12ga 12ga 12ga 12ga 12ga

RPC 25A

User Bus A

Return

12ga 12ga

12ga 12ga 12ga

J7

1 TSP 22ga

MSS Local Bus B (LB1 B)

1 TSP 22ga

1 TSP 22ga

1 TSP 22ga

PFM Video 3

SSBA RD316

RD316 RD316 J2 12ga 12ga J6

RD316 RD316

PFM Sync and Control 2 RD316

User Bus B RPC 25A

Return

Payload Power B1 12ga Return B1 Payload Power B2

Return B2 Ground

12ga 12ga 12ga 12ga 12ga

12ga

12ga

12ga 12ga

12ga J4

J8

FIGURE A3.4­2 PDGF TO USER (VIA POA) ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM

A3 ­ 8

Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï

User Determined PDGF Harness Length

Data Bus A

J5

To User Loads

J7

Data Bus B

J6

To User Loads

J8

ÉÉ ÉÉ

ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï ÏÏ Ï

Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï Ï

SSP 42004, Part 2

MSS to User ICD May 22, 1997

TBD #1

FIGURE A3.4­3 PDGF TO USER (VIA SPDM) ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM

A3 ­ 9

SSP 42004, Part 2

MSS to User ICD May 22, 1997

JEM to PDGF Interface Plane NASDA Connector Panel

2

8ga

12ga

2 1

8ga

12ga

8ga 12ga

2

8ga

2 1

8ga

8ga 12ga

JEM Heaters

JEM Heaters

Notes: 1) VSC not shown. 2) Total keep­alive power drawn will include VSC keep­alive power as defined in SSP 42003, Section H.

FIGURE A3.4­4 JEM­PM TO PDGF KEEP­ALIVE ELECTRICAL SYSTEM DIAGRAM

A3 ­ 10

ÓÓ ÓÓ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ

To VSC J2

NASDA Harnesses and Connectors

PDGF Harnesses and Connectors 2 2 2 2 1

ÑÑÑÑÑÑÑÑ ÑÑÑÑÑÑÑÑ ÑÑÑÑÑÑÑÑ ÑÑÑÑÑÑÑÑ ÓÓÓÓÓÓÓÓ ÓÓÓÓÓÓÓÓ ÓÓÓÓÓÓÓÓ Ñ Ñ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓÓ Ó Ñ ÓÓ Ó ÑÓ Ñ Ñ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓÓ Ó Ñ

12ga

J 7

12ga

To VSC J2 To VSC J3

J E M P D G F

Resources From SSRMS

12ga

2 2 2 2 1

12ga

12ga

12ga

J 8

Resources From SSRMS

To VSC J3

NASDA Connectors PDGF Connectors

SSP 42004, Part 2

MSS to User ICD May 22, 1997

APM to PDGF Interface Plane ESA Connector Panel

ESA Harnesses and Connectors

PDGF Harnesses and Connectors 12ga 2 2 2 2 1

2

8ga

2 1

8ga

8ga 12ga

2

8ga

2 1

8ga

8ga 12ga

APM Heaters

APM Heaters

BC

BC

Heater Control Unit

Heater Control Unit

FIGURE A3.4­5 APM TO PDGF KEEP­ALIVE ELECTRICAL SYSTEM DIAGRAM

A3 ­ 11

ÓÓ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ ÑÑÑ

1 TSP J5 1 TSP J6 12ga J 7 12ga 12ga

ÑÑÑÑ ÑÑÑÑ ÑÑÑÑ ÑÑÑÑ ÑÑÑÑÑÑ ÑÑÑÑ ÑÑÑÑ ÑÑÑÑÑÑÑÑÑÑÑÑÑ ÑÑÑÑÑÑÑ ÑÑÑÑÑÑÑÑÑ ÑÑÑÑÑÑÑÑÑ ÓÓÓÓÓÓÓÓÓ ÓÓÓÓÓÓÓÓÓ ÓÓÓÓÓÓÓÓÓ Ñ Ñ ÓÓÓ Ó Ñ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ Ñ Ñ ÓÓÓ Ó Ñ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó ÑÓ ÓÓ Ó Ñ ÑÓ Ñ ÓÓ Ó Ñ Ó Ó ÑÓ Ó Ó ÑÓ Ó Ó ÑÓ Ó Ó ÓÓ Ó ÑÓ ÓÓ Ó Ñ ÓÓ Ó Ñ ÓÓ Ó Ñ ÓÓ Ó Ñ ÓÓ Ó Ñ

A P M P D G F

Resources From SSRMS

12ga

2 2 2 2 1

12ga

12ga 12ga

J 8

Resources From SSRMS

ESA Connectors PDGF Connectors

Note 1) The MSS LB termination is shown for reference only.

ÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Notes: 1) Power quality characteristics at this interface shall meet the interface "C" power quality requirements in SSP 30482 except for minimum voltage. 52 51 50 49 35 Contact ID

5) For connector part numbers, refer to Figure A3.2­3.

4) Connector specifications are as per SSQ 21635.

3) Nominal rating of CRPCM output port, as defined in SSP 42004, Section A, Part 1.

2) Table reflects design to peak power requirements and the associated minimum voltage at the LEE/PDGF interface plane.

SSP 42004, Part 2

TABLE A3.4.2­1 PDGF POWER FROM SSRMS (PRIME) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J7)

Return 2

Payload Power Bus 2

Return 1

Payload Power Bus 1

Ground

Signal Function

1.8

1.8

1.8

1.8

1.8

Peak 2 Power

(kW)

POWER SPECIFICATIONS

108.5

108.5

108.5

108.5

0

Minimum Voltage

(VDC)

A3 ­ 12 25 25 25 25 25 Maximum Current 3 [A] EO EO EO EO EO EMC Class MSS to User ICD May 22, 1997 N/A C C C C Power 1 Quality Type 12 12 12 12 12 Wire Gauge (ga)

SSP 42004, Part 2

MSS to User ICD May 22, 1997

TABLE A3.4.2­2 PDGF POWER FROM SSRMS (REDUNDANT) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J8)

ÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

POWER SPECIFICATIONS

Minimum Voltage (VDC) Maximum Current 3 [A] Contact ID Signal Function Peak Power (kW)

2

EMC Class

Power 1 Quality Type C

Wire Gauge (ga)

35

Ground

1.8

0

25

EO

12

49

Payload Power Bus 1 Return 1

1.8

108.5

25

EO

12

C

50

1.8

108.5

25

EO

C

12

51

Payload Power Bus 2

1.8

108.5

25

EO

C

12

N/A Return 2 52 1.8 108.5 25 EO 12 Notes: 1) Power quality characteristics at this interface shall meet the interface "C" power quality requirements in SSP 30482, except for minimum voltage.

2) Table reflects design to peak power requirements and the associated minimum voltage at the LEE/PDGF interface plane. 3) Nominal rating of CRPCM output port, as defined in SSP 42004, Section A, Part 1. 4) Connector specifications are as per SSQ 21635. 5) For connector part numbers, refer to Figure A3.2­3.

A3 ­ 13

ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

TABLE A3.4.2­3 PDGF POWER FROM POA (PRIME) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J7)

SSP 42004, Part 2 51 50 49 35 Contact ID Payload Power Bus 2 Return 1 Payload Power Bus 1 Ground Signal Function 1.8 1.8 1.8 1.8 Peak Power 2 (kW)

5) For connector part numbers, refer to Figure A3.2­3.

4)Connector specifications are as per SSQ 21635.

3) Nominal rating of CRPCM output port, as defined in SSP 42004, Section A, Part 1.

N/A Return 2 52 1.8 113 25 EO 12 Notes: 1) The Transient Voltage Limits & Time Duration are as defined in SSP 30482. 2) Table reflects design to peak power requirements and the associated minimum voltage at the POA/PDGF interface plane.

POWER SPECIFICATIONS

113

113

113

0

Minimum Voltage

(VDC)

A3 ­ 14 25 25 25 25 Maximum Current 3 [A] EO EO EO EO EMC Class MSS to User ICD May 22, 1997 C C C C Power 1 Quality Type 12 12 12 12 Wire Gauge (ga)

ÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Notes: 1) The Transient Voltage Limits & Time Duration are as defined in SSP 30482. SSP 42004, Part 2 52 51 50 49 35 Contact ID

5) For connector part numbers, refer to Figure A3.2­3.

4) Connector specifications are as per SSQ 21635.

3) Nominal rating of CRPCM output port, as defined in SSP 42004, Section A, Part 1.

2) Table reflects design to peak power requirement and the associated minimum voltage at the POA/PDGF interface plane.

TABLE A3.4.2­4 PDGF POWER FROM POA (REDUNDANT) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS (J8)

Return 2

Payload Power Bus 2

Return 1

Payload Power Bus 1

Ground

Signal Function

1.8

1.8

1.8

1.8

1.8

Peak Power

(kW)

2

POWER SPECIFICATIONS

113

113

113

113

0

Minimum Voltage

(VDC)

A3 ­ 15 25 25 25 25 25 Maximum Current 3 [A] EO EO EO EO EO EMC Class MSS to User ICD May 22, 1997 N/A C C C C Power 1 Quality Type 12 12 12 12 12 Wire Gauge (ga)

ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Notes: 1) Specific local bus that supports payloads depends on location of SSRMS. SSP 42004, Part 2 36 35 34 44 47 Contact ID

2) Connector specifications are as per SSQ 21635.

TABLE A3.4.3.1­1 PDGF DATA AND VIDEO FROM SSRMS (PRIME) CONNECTORS AND PIN ASSIGNMENTS (J5)

Sync and Control 1

Video Channel 2

Video Channel 1

MSS LB1 A Lo

MSS LB1 A Hi

Signal Function

CONNECTOR SPECIFICATIONS

RF

RF

RF

RF

RF

EMC Type

A3 ­ 16 Remarks 1) 1) MSS to User ICD May 22, 1997

ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Notes: 1) Specific local bus that supports payloads depends on location of SSRMS.

2) Connector specifications are as per SSQ 21635.

TABLE A3.4.3.1­2 PDGF DATA AND VIDEO FROM SSRMS (REDUNDANT) CONNECTORS AND PIN ASSIGNMENTS (J6)

SSP 42004, Part 2

36

34

44

47

Contact ID

Sync and Control 2

Video Channel 3

MSS LB1 B Lo

MSS LB1 B Hi

Signal Function

CONNECTOR SPECIFICATIONS

RF

RF

RF

RF

EMC Type

A3 ­ 17 Remarks 1) 1) MSS to User ICD May 22, 1997

ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁ ÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Notes: 1) Connector specifications are as per SSQ 21635. SSP 42004, Part 2

TABLE A3.4.3.1­3 PDGF DATA AND VIDEO FROM POA (PRIME) CONNECTORS AND PIN ASSIGNMENTS (J5)

36

35

34

44

47

Contact ID

CONNECTOR SPECIFICATIONS

Sync and Control 1

Video Channel 2

Video Channel 1

MSS LB1 A Lo

MSS LB1 A Hi

Signal Function

RF

RF

RF

RF

RF

EMC Type

A3 ­ 18 Remarks MSS to User ICD May 22, 1997

ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Notes: 1) Connector specifications are as per SSQ 21635. SSP 42004, Part 2 36 34 44 47 Contact ID

TABLE A3.4.3.1­4 PDGF DATA AND VIDEO FROM POA (REDUNDANT) CONNECTORS AND PIN ASSIGNMENTS (J6)

CONNECTOR SPECIFICATIONS

Sync and Control 2

Video Channel 3

MSS LB1 B Lo

MSS LB1 B Hi

Signal Function

RF

RF

RF

RF

EMC Type

A3 ­ 19 Remarks MSS to User ICD May 22, 1997

ÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁ Á Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁ Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

Payload at MBS POA Payload at SSRMS LEE Link

SSP 42004, Part 2

TABLE A3.4.4­1 VIDEO PROVISIONS FOR USERS

A3 ­ 20 Video Channels From Payload Video Channels From Payload Video Sync Channels To Payload Video Sync Channels to Payload Communication Type MSS to User ICD May 22, 1997 3 2 3 2 # of Channels

SSP 42004, Part 2

MSS to User ICD May 22, 1997

TABLE A3.4.4­2 DELETED

A3 ­ 21

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION B3 MCAS TO USER INTERFACE

B3 INTERFACE DEFINITION

B3.1 GENERAL

B3.1.1 INTERFACE DESCRIPTION

The physical interface (mechanical, structural, thermal and environmental) plane is defined between the active half of the MBS CAS (MCAS) and the passive half of the User. The utility interface plane (power and data ) is defined between the MCAS Umbilical Mechanism Assembly (UMA) connector and User connector. There are no video interfaces between the MCAS and the User.

B3.1.2 DELETED

B3.1.3 ENGINEERING UNITS AND TOLERANCES

Unless otherwise noted herein, all dimensions are shown in the English system of inch pound (IP) units.

B3.2 STRUCTURAL/MECHANICAL INTERFACES

The MCAS provides the active half of the interface consisting of three V­guides, one latch, and one UMA for interfacing with the User. The User provides the passive half consisting of three guide pins, a capture bar, and passive UMA electrical connectors. The MCAS mechanical and structural details are defined in Figures B3.2­1 through B3.2­3.

B3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

B3.3 DELETED

B3.4 ELECTRICAL INTERFACES

The MCAS to User power and data interfaces will be as defined in Figure B3.4­1.

B3.4.1 POWER, RETURN AND GROUNDING INTERFACES

The MCAS to User power, return and grounding interfaces will be as defined in Figure B3.4­1.

B3.4.2 POWER CONNECTORS AND PIN ASSIGNMENTS

The power connectors and pin assignments between the MCAS and the User will be as defined in Table B3.4.2­1.

B3.4.3 DATA INTERFACES

The C & DH subsystem will support data interfaces between the MCAS and the User as defined in Figure B3.4­1.

B3.4.3.1 DATA CONNECTORS AND PIN ASSIGNMENTS

The data connectors and pin assignments between the MCAS and the User will be as defined in Table B3.4.2­1.

B3.5 ENVIRONMENTS

The MCAS to User electromagnetic, grounding and bonding interface implementation will be as defined in Figures B3.2­1 through B3.2­3.

B3.6 SOFTWARE INTERFACES

There are no software interfaces between the MCAS and the User.

B3 ­ 2

SSP 42004, Part 2

MSS to User ICD May 22, 1997

(Reference SPAR Drawing 51800­0025, Sheet 1 of 3)

FIGURE B3.2­1 MCAS TO USER MECHANICAL INTERFACE

B3­ 3

SSP 42004, Part 2

MSS to User ICD May 22, 1997

(Reference SPAR Drawing 51800­0025, Sheet 2 of 3)

FIGURE B3.2­2 MCAS TO USER MECHANICAL INTERFACE

B3 ­ 4

SSP 42004, Part 2

MSS to User ICD May 22, 1997

(Reference SPAR Drawing 51800­0025, Sheet 3 of 3)

FIGURE B3.2­3 MCAS TO USER MECHANICAL INTERFACE

B3­5

SSP 42004, Part 2

MSS to User ICD May 22, 1997

P/L RT

User Address 21 To User

P/L RT

Ground J Reserved

FIGURE B3.4­1 MCAS TO USER ELECTRICAL INTERFACE AND CURRENT PROTECTION DIAGRAM

B3­ 6

SSP 42004, Part 2

MSS to User ICD May 22, 1997

TABLE B3.4.2­1 MCAS TO USER PRIME AND REDUNDANT POWER AND DATA CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS

ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á Á Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁ Á ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ

CONNECTOR ID

MCAS Ref. Des: P11 User Ref. Des: J Reserved Part Number: NUP1­005 Part Number: Reserved

POWER AND DATA SPECIFICATIONS

Minimum Voltage (VDC) NA NA NA NA 112.5 112.5 112.5 112.5 112.5 112.5 Current3 [A] NA NA NA NA 12 12 12 12 12 12 RF RF RF RF EO EO EO EO EO EO NA NA NA NA C C C C N/A N/A EMC Class

ContactID Signal Function

Peak Power2 (W)

Power1) Quality Type

Wire Gauge (ga) 22 22 22 22 8 8 8 8 8 8

Remarks

TBD#12 TBD#13 TBD#12 TBD#13 TBD#12 TBD#13 TBD#12 TBD#13 TBD#12 TBD#13

LB A Hi LB B Hi LB A Lo LB B Lo User Power Bus 1 User Power Bus 2 Return 1 Return 2 Ground Ground

NA NA NA NA 1350 1350 1350 1350 1350 1350

RT ADDRESS 21

Notes: 1) The Transient Voltage Limits & Time Duration are as defined in SSP 30482, except for minimum voltage. 2) Table reflects design to peak power requirement and the associated minimum voltage defined at the MCAS UMA to User UMA interface plane. 3) Nominal rating of the MBS CRPCM output port. 4) Refer to SSQ 21635 for connector detailed specifications

B3­ 7

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION C3 RESERVED RESERVED

C3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION D3 RESERVED RESERVED

D3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION E3 RESERVED RESERVED

E3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION F3 RESERVED RESERVED

F3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION G3 RESERVED RESERVED

G3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION H3 RESERVED RESERVED

H3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SECTION I3 FRGF TO USER INTERFACES

I3 INTERFACE DEFINITION

The FRGF to user interface design details are documented in NSTS­21000­IDD­ISS, Shuttle Orbiter/International Cargo Standard Interfaces, Section 14.0.

I3 ­ 1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

APPENDIX A: ABBREVIATIONS AND ACRONYMS

AVF AVU CAS CCTV CSA DHT EFGF EMI EVA FRGF ft Hz ICD in IP kbps kg kN­m kW lbs LEE m mA MBS

Artificial Vision Function Artificial Vision Unit Common Attach Structure Closed Circuit Television Canadian Space Agency Dexterous Handling Target Electrical Flight Grapple Fixture Electromagnetic Interference Extravehicular Activity Flight Releasable Grapple Fixture feet Hertz Interface Control Document inch International Partner kilo bits per second kilograms kiloNewton­meter kilowatt pounds Latching End Effector meter milliamps MRS Base System

A­1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

MC MCAS MCE MCF MRS MSC MSS MT NASA N NSTS ORU OTCM OTP PDGF PFM POA PSA PWP rad RSGF RT SDGF SEE SI SPDA

Micro Conical MBS CAS MSS Control Equipment Micro Conical Fitting Mobile Remote Servicer Mobile Servicing Center Mobile Servicing System Mobile Transporter National Aeronautics and Space Administration Newton National Space Transportation System Orbit­Replaceable Unit ORU/Tool Changeout Mechanism ORU/Tool Platform Power and Data Grapple Fixture Pulse Frequency Modulation Payload/ORU Accommodation Payload/ORU Support Assembly Portable Workplatform Radian Rigidize Sensing Grapple Fixture Remote Terminal Standard Dexterous Grasp Fixture Standard End Effector Systems International Secondary Power Distribution Assembly

A­ 2

SSP 42004, Part 2

MSS to User ICD May 22, 1997

SPDM SPEE SSCB SSRMS TBD TBR TUS UMA Vdc W

Special Purpose Dexterous Manipulator Special Purpose End Effector Space Station Control Board Space Station Remote Manipulator System To Be Determined To Be Reviewed Trailing Umbilical System Umbilical Mechanism Assembly Volts, direct current Watts

A­ 3

SSP 42004, Part 2

MSS to User ICD May 22, 1997

APPENDIX B: ISSUE SHEETS

B­1

SSP 42004, Part 2

MSS to User ICD May 22, 1997

ISSUE FORM, SPACE STATION Issue Title:

Initiator Name: Org/Company: Phone: Mailcode: Document ID: Title: Date:

Issue No.

42004­02­TC­01

Drawing Impact due to Change on Bonding Specification Tom Craig Boeing/Huntsville 205­461­6029 SSP 42004, Revision A MSS to User ICD, Part 2 5/22/97 Date: 7/3/97 Initiator's Issue No: Problem Category: (Mandatory only) Page #: Sec. #: Para. #: Fig. #: A3­4 A A3.2­1

Description of Issue: Previous versions of these documents have only required a Class H and R bond, which PG­3 implemented in their interface design. Note 9, added to this page since the February draft, imposes a specific implementation of the Class R bond which is different from the one used in our released drawings. Although the change to he drawing is minor in nature, we need authorization to make the change.

Recommendation:

Impact if Recommendation Not Implemented:

B­2

SSP 42004, Part 2

MSS to User ICD May 22, 1997

APPENDIX C: TBD LIST 1 2 3 4 5 A3.4 ELECTRICAL INTERFACES (SPDM) A3.4.2 POWER CONNECTORS AND PIN ASSIGNMENTS (SPDM) A3.7 PDGF STANDARD GRAPPLE TARGET AND AVF TARGET A3­2 A3­2 A3­3 2­21­97

TABLE A3.4.2­1 PDGF TO USER POWER FROM SSRMS (PRIME) A3­13 2­21­97 CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS TABLE A3.4.2­2 PDGF TO USER POWER FROM SSRMS (REDUNDANT) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS TABLE A3.4.2­3 PDGF TO USER POWER FROM POA (PRIME) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS TABLE A3.4.2­4 PDGF TO USER POWER FROM POA (REDUNDANT) CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS TABLE A3.4.3.1­1 PDGF TO USER DATA AND VIDEO FROM SSRMS (PRIME) CONNECTORS, AND PIN ASSIGNMENTS A3­14 2­21­97

6 7

A3­15 2­21­97 A3­16 2­21­97

8 9 10 11 12 13

A3­17 2­21­97

TABLE A3.4.3.1­2 PDGF TO USER DATA AND VIDEO FROM A3­18 2­21­97 SSRMS (REDUNDANT) CONNECTORS, AND PIN ASSIGNMENTS TABLE A3.4.2­3 PDGF TO USER DATA AND VIDEO FROM POA (PRIME) CONNECTORS, AND PIN ASSIGNMENTS TABLE A3.4.2­4 PDGF TO USER DATA AND VIDEO FROM POA (REDUNDANT) CONNECTORS, AND PIN ASSIGNMENTS TABLE B3.4.2­1 MCAS TO USER PRIME POWER AND DATA CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS TABLE B3.4.2­2 MCAS TO USER REDUNDANT POWER AND DATA CHARACTERISTICS, CONNECTORS, AND PIN ASSIGNMENTS A3­19 2­21­97 A3­20 2­21­97 B3­9 B3­9

B3­10 B3­10

B­1

Information

53 pages

Report File (DMCA)

Our content is added by our users. We aim to remove reported files within 1 working day. Please use this link to notify us:

Report this file as copyright or inappropriate

182812